concrete made with quarry dust as aggregate

concrete made with quarry dust as aggregate

High Performance Concrete using Quarry dust as Fine

2016-2-29 · Cement Fine aggregate (quarry dust) Coarse aggregate Super plasticizer 168.3 60.0 600.8 566.7 1108.4 30.04 0.29 10% 1 0.9 1.8 5 3, EXPERIMENTAL WORK 3.1 Slump Cone Test The slump test is most commonly used method of measuring consistency of concrete which can be employed either in laboratory or at site of work. ...

The Utilization of Quarry Dust as Fine Aggregates in

75% & 100% in concrete & cubes were casted using this concrete containing quarry dust. The compressive strength of these cubes were tested after 7 days, 21 days & 28 days & the results thus obtained were compared to the compressive strength of the cubes made up of conventional concrete containing no quarry dust. 5 Results and Discussions

Strength of Concrete with Ceramic Waste and Quarry Dust

From the results show that compressive strength of concrete with quarry dust as aggregates is the highest with 30.82 MPa with density 2251.85 kg/m 3 . This show, ceramic waste and quarry dust can ...

Study on Performance of Quarry Dust as Fine Aggregate in ...

2018-3-7 · The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%,

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15 · Keywords: - Quarry dust, Sand, Concrete, Compressive strength. INTRODUCTION:- Quarry dust is a byproduct of the crushing process which is a concentrated material to use as aggregates for concreting purpose, especially as fine aggregates. In quarrying activities, the rock has been crushed into various sizes; during the process the dust generated ...

Strength of Concrete with Ceramic Waste and Quarry Dust

This research focuses on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The sources of ceramic waste and quarry dust are obtained from the industrial in Malaysia. Presently, in ceramics industries the production goes as waste, which is not under going the recycle process yet. In this study an attempt has been made to find the ...

Use of Quarry Fine as Partial Replacement of Concrete as

2014-10-10 · combinations of lateritic sand and quarry dust as complete replacement for conventional river sand fine aggregate. Samples of concrete cube were made using varying contents of laterite and quarry dust as fine aggregate. The quantity of laterite was varied from 0% to 100% against quarry dust at intervals of 25%.

Introduction to Quarry-Dust as Partial Replacement ...

2020-5-19 · To study the durability and strength of concrete tests were conducted on cubes and beams made of quarry dust and the results were compared with the natural sand concrete. The compressive strength, flexural strength and durability. studies of concrete made of quarry dust shown results that are nearly 10% more than the conventional concrete.

Effect of quarry rock dust on the flexural strength of ...

2018-6-1 · Portland limestone cement, river sand and quarry rock dust both of 2 mm maximum size as fine aggregate, and 14 mm crushed rock coarse aggregate were used for the concrete The particle size distribution and the physical properties of the fine and coarse aggregates are shown in Fig. 1 and Table 1 respectively. The fine and coarse aggregates satisfied the BS EN 12620:2002 + A1:2008 specifications.

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

2018-11-5 · EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL REPLACEMENT OF CEMENT AND FINE AGGREGATE IN CONCRETE I Rohini 1(Department of Civil, Jeppiar SRR Engineering College, India) V.Arularasi 2(Depatment of civil,Jeppiar SRR engineering College,India) ABSTRACT: FLY ASH CONTAINS THE BASIC INGREDIENTS OF CEMENT LIKE SILICA, MAGNESIUM AND CALCIUM.

High Performance Concrete using Quarry dust as Fine

2016-2-29 · Cement Fine aggregate (quarry dust) Coarse aggregate Super plasticizer 168.3 60.0 600.8 566.7 1108.4 30.04 0.29 10% 1 0.9 1.8 5 3, EXPERIMENTAL WORK 3.1 Slump Cone Test The slump test is most commonly used method of measuring consistency of concrete which can be employed either in laboratory or at site of work. ...

The Utilization of Quarry Dust as Fine Aggregates in

75% & 100% in concrete & cubes were casted using this concrete containing quarry dust. The compressive strength of these cubes were tested after 7 days, 21 days & 28 days & the results thus obtained were compared to the compressive strength of the cubes made up of conventional concrete containing no quarry dust. 5 Results and Discussions

Strength of Concrete with Ceramic Waste and Quarry Dust

This research focuses on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The sources of ceramic waste and quarry dust are obtained from the industrial in Malaysia. Presently, in ceramics industries the production goes as waste, which is not under going the recycle process yet. In this study an attempt has been made to find the ...

Comparing the Compressive Strengths of Concrete Made

Optimization of Concrete Made with Abakaliki Quarry Dust as Fine Aggregate Using Scheffe’s Optimization Model ... "Comparing the Compressive Strengths of Concrete Made with River Sand and Quarry Dust as Fine Aggregates", International Letters of Natural Sciences, Vol. 20, pp. 179-189, 2014

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15 · Keywords: - Quarry dust, Sand, Concrete, Compressive strength. INTRODUCTION:- Quarry dust is a byproduct of the crushing process which is a concentrated material to use as aggregates for concreting purpose, especially as fine aggregates. In quarrying activities, the rock has been crushed into various sizes; during the process the dust generated ...

Comparing the Compressive Strengths of Concrete Made

Comparing the compressive strengths of concrete made with river sand and quarry dust as fine aggregates Chijioke Chiemela1, fgwegbe talter1, Ibearugbulem Ogedi1, Okoye meter2, Oke Mong2 1Civil Engineering Department, Federal Polytechnic Nekede, Owerri, Imo State, Nigeria 2Mechanical Engineering Department, Federal Polytechnic Nekede Owerri Imo State, Nigeria

Effect of Quarry Dust on High Performance Concrete

2017-2-2 · concrete mixtures. Usually, Quarry Rock Dust is used in large scale in the highways as a surface finishing material and also used for manufacturing of hollow blocks and lightweight concrete prefabricated Elements. Use of Quarry rock dust as a fine aggregate in concrete draws serious attention of researchers and investigators.

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water. Rapid increase in construction activities leads to acute shortage of conventional

Partial Replacement of Sand by Quarry Dust in Concrete

2021-6-4 · investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Effect of Replacement of Natural Sand by M-Sand as Fine ...

2015-1-1 · performance concrete using quarry dust as fine aggregate” vol-2 issue: 2, issn_no:2320-723x, jun-2014 [3] Anita selva Sofia S.D, Gayathri.R and Swathi.G “Experimental investigation on quarry dust concrete with chemical admixture” vol-2, issue-2, 2013 [4]

Comparing the Compressive Strengths of Concrete Made

Optimization of Concrete Made with Abakaliki Quarry Dust as Fine Aggregate Using Scheffe’s Optimization Model ... "Comparing the Compressive Strengths of Concrete Made with River Sand and Quarry Dust as Fine Aggregates", International Letters of Natural Sciences, Vol. 20, pp. 179-189, 2014

Experimental Investigation on Quarry Dust Concrete with ...

quarry dust have been made in India. Quarry dust, the waste material that causes disposal problem is made as a valuable resource by the successful utilization of this quarry dust as a fine aggregate and this will also overcome the strain on supply of river sand as fine aggregate and also the cost will be reduced.

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15 · Keywords: - Quarry dust, Sand, Concrete, Compressive strength. INTRODUCTION:- Quarry dust is a byproduct of the crushing process which is a concentrated material to use as aggregates for concreting purpose, especially as fine aggregates. In quarrying activities, the rock has been crushed into various sizes; during the process the dust generated ...

Effect of Quarry Dust on High Performance Concrete

2017-2-2 · concrete mixtures. Usually, Quarry Rock Dust is used in large scale in the highways as a surface finishing material and also used for manufacturing of hollow blocks and lightweight concrete prefabricated Elements. Use of Quarry rock dust as a fine aggregate in concrete draws serious attention of researchers and investigators.

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water. Rapid increase in construction activities leads to acute shortage of conventional

PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

2019-4-21 · corrosion resistance behavior of inhibitors in concrete containing quarry dust as fine aggregate,” Journal of Engineering and Applied Sciences, vol. 6, no. 11, pp. 124–135, 2011. [12] R. P. Nanda, A. K. Das, and N. Moharana, “Stone crusher dust as a fine aggregate in concrete for paving

Studies on Quarry Dust as Partial Replacement of Fine ...

2017-4-30 · made to utilize quarry dust as a partial substitute for natural sand in producing concrete. Natural sand is replaced by Quarry dust at an interval of 5%, 10%, 15%, 20% and 25%. ... partial substitute for fine aggregate in concrete. The evaluation is based on parameters such as gradation results, workability, compressive strength and flexural ...

Partial Replacement of Sand by Quarry Dust in Concrete

2021-6-4 · investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Effect of Replacement of Natural Sand by M-Sand as Fine ...

2015-1-1 · performance concrete using quarry dust as fine aggregate” vol-2 issue: 2, issn_no:2320-723x, jun-2014 [3] Anita selva Sofia S.D, Gayathri.R and Swathi.G “Experimental investigation on quarry dust concrete with chemical admixture” vol-2, issue-2, 2013 [4]

Compressive Strength of Concrete Using Sawdust as

2016-9-9 · compressive strength of concrete decreased as the percentage replacement increased but replacement of sand by sawdust produced a higher percentage reduction in compressive strength than in density. Sawdust can potentially be used as aggregate in the production of both non-structural lightweight concrete and structural concrete.